Motorcycle Repair: 2004 kawi 636, 30 amp fuse, fuse box

Question
i rode my bike home the other day from work parked it but didn't turn the key off. i went to crank it the next day and battery was dead i tried to charge the battery on the charger and ended up replacing the battery. it still wont start no power at all. my led lights that i have hooked up off the battery come on just no power to the bike at all

Answer
Hi Glenn,

If your battery is good and the cables
are tightly connected the power then
goes to the starter relay. The bike's
main fuse is on the starter relay.

It is located on the left side when
sitting on the bike just under
the front left side of the seat.

There should be a 30 amp fuse there.

Once the power gets through that main fuse
on the relay it goes to the other fuse box near the
rear of the bike under the seat.
This fuse box has the ECU main fuse in it.

If all the fuses are okay the next
thing to check would be the relays on the left
rear under the seat also.

Also a faulty ignition switch could be
a possibility at times.

Remember the ground circuit is important
too. Check the battery ground cable
connections to the battery and to the frame.

Good luck!
Wayne S.
--------------